Page 1 of 1

CRF250R Rebuild - Mystery Item??

Posted: Wed Jul 26, 2017 11:43 am
by Ewan2k_uk
Hey folks,

I've recently purchased a 2006 CRF250R, this was bought spares or repair and upon rebuilding the bottom end and following the service manual and microfiche I have somehow ended up with a large washer with two internal lugs left over. I cant seem to identify it anywhere on any microfiche?

Can anyone help me out ](*,)

https://photos.app.goo.gl/CLlBAu5Vh1rIVmc33

Thanks
Ewan

Re: CRF250R Rebuild - Mystery Item??

Posted: Wed Jul 26, 2017 7:19 pm
by JimDirt
Welcome to the site !! \:D/

I just looked thru the Factory Service Manual , as well as the parts Fiche and can't seem to locate it either , what it would appear to me is the notches would go over a spline , so i would be looking in the transmission or clutch for its location

You might PM (Private Message) Ken the owner here , its been a few years since i had a 250 apart and can't recognize that washer/bushing offhand , but i am sure he has had several 250's apart in the last few months and would most likely recognize it

That's about the best help i can offer at this point :?

Ken:
https://www.crfsonly.com/forum/memberli ... rofile&u=3